industrial 2t natural gas fired boiler manufacturers brunei, ZOZEN horizontal low nox condensing gas-fired steam boiler is preferred by users

industrial 2t natural gas fired boiler manufacturers brunei, With air emission regulations constantly changing, ZOZEN Boiler has adopted new ways to keep up with more stringent standards. ZOZEN eco-friendly boilers were launched to the market, which come in various sizes. These eco-friendly boilers are more superior and efficient unlike traditional boilers as they smartly recycle heat that would be wasted.

The condensate water draining performance plays an essential role in the normal operation of gas-fired boiler to prevent the emission of steam when condensate water, air and carbon dioxide are discharged. Intended to realize a better effect of water draining and steam holding, ZOZEN Boiler’s technical team improved the original boiler structure for excellent condensate water draining performance to reduce energy consumption and cut down production cost for the enterprise.

industrial 2t natural gas fired boiler manufacturers brunei, ZOZEN’s YQ(Y)L series oil-fired/gas-fired vertical thermal oil heater adopts three-pass round coil structure whose end adopts conical coil which can effectively protect the furnace wall at the end of boiler. It is equipped with advanced combustion device with good energy saving and environmental protection performance. This kind of boiler has the characteristics of wide fuel adaptability, low pressure and high temperature, safety and efficiency, high thermal efficiency over 95%, and complete automatic control system which can realize unattended operation.

With thermal efficiency over 82% and NOx emissions less than 100mg/Nm3, ZOZEN DZL series boilers feature high efficiency and low emissions. They adopt single-drum structure and a chain grate. The heat transfer coefficient of threaded smoke tubes is 1.8 times higher than ordinary tubes. In order to expand the capacity, PT. New Hope Indonesia introduced ZOZEN DZL series coal-fired steam boiler to provide efficient and reliable heat source guarantee for feed production. 

The grate bracket adopts double brackets, the lower channel steel, the upper light rail, the upper heat, the lower force, which has changed the structure of the traditional grate bracket angle steel plus friction bar, the grate bracket is not deformed. The active stoker is operated on the light rail and it is tested in the cold state for 48 hours before leaving the factory. Never run sideways, stuck, which ensure the smooth operation of the stoker, industrial 2t natural gas fired boiler manufacturers brunei.

industrial 2t natural gas fired boiler manufacturers brunei, In ZOZEN’s blanking workshop, all steel plates, steel pipes and other parts are given unique electronic codes throughout the whole production, equipment and service links. This information-based logistics mode not only shortens the distance between production and logistics supply, but also lays a good foundation for future expansion of production lines and application of new technologies, so as to improve the entire upstream and downstream production efficiency and economic benefits.

All boilers are subject to damage if proper water treatment procedures are not followed. This is an important consideration both during operation and when the boiler is idle. To avoid damage and costly repairs, monitor water chemistry routinely and ensure that you are supplying your boiler with soft water at all times.