11tons biomass fired steam boiler, ZOZEN gas-fired boilers are listed in the first batch of national high-efficient and energy-saving boiler promotion catalogs

Improper water treatment is the leading cause of tube damage and poor performance in a boiler system. In this month, ZOZEN will discuss the consequences of introducing your boiler to hard water and the importance of utilizing a water softener.

11tons biomass fired steam boiler, Under the background of increasingly fierce market competition and rising comprehensive costs, Mengniu Dairy always adheres to the concept of sustainable development. When purchasing boiler equipment, it uses clean energy natural gas as fuel to reduce environmental pollution. So far, Mengniu Dairy has purchased more than ten sets of WNS series gas-fired steam boilers from ZOZEN.

The DZL series biomass-fired horizontal three-pass water-fire tube chain grate boiler is pre-assembled boiler with a capacity of 2-20 tph (hot water boiler: 1.4-14MW) and a thermal efficiency of over 88%. By extending the furnace arch, increasing the furnace height and adjusting the width and length of grate, ZOZEN takes the lead in solving the problems that easily occur in biomass-fired boilers such as furnace arch collapse, furnace door burnout, hopper tempering and tube wall coking. It has the characteristics of wide fuel adaptability, small covering area, convenient installation and high thermal efficiency.

11tons biomass fired steam boiler, ZOZEN’s oil-fired/gas-fired skid-mounted steam boiler has obvious advantages of integrated skid-mounted delivery, compact structure and cost saving, which immediately attracted the attention and favor of the Myanmar Factory of Xindaxin Food after it came onto the market. ZOZEN had completed the customization of full set of skid-mounted boiler system to meet the actual requirements of the factory. After it is delivered to the boiler room of the Myanmar factory, it can run automatically with water, electricity and oil supply when the start button is pressed.

ZOZEN WNS series gas fired boiler not only adopts advanced low NOx burners. And through the flue gas recirculation technology, about 10% -30% of the flue gas at the tail of the boiler is sucked into the air inlet of the burner through the flue gas pipe, mixed with the combustion-supporting air, and then entering the furnace, thereby reducing the temperature and oxygen concentration in the combustion area, and finally reducing The amount of thermal NOx is generated, and the NOx in the tail gas of the boiler are less than 30mg/Nm3, which meets the requirements of low nitrogen emissions of the enterprise.enterprise, 11tons biomass fired steam boiler.

The header is not an independent component, but a component consisting of water-cooled walls, economizer, superheater and other components. Therefore, there are water-cooled wall header, economizer header, superheater header and so on. The function of header is to collect or distribute the steam and water working medium, reduce the transmission and connection pipes of working medium, reduce the number of drum holes, so as to improve the safety performance of drum, 11tons biomass fired steam boiler.

ZOZEN Boiler provides temporary and permanent solutions with our profession for industrial boilers to meet the most stringent emissions requirements. If you need more information, please contact us today.