factory price industrial 4t gas boiler vietnam, ZOZEN steam boilers are clean and eco-friendly with low NOx emissions

The new era creates new demands. As the economic growth gradually changes from extensive type to intensive and eco-friendly type, all industries are facing unlimited opportunities and challenges. ZOZEN Boiler, as a typical representative of industrial boiler manufacturers, has promoted the transformation and upgrading of various industries with the eco-friendly gas-fired boilers, which not only helps the cooperative partners of ZOZEN Boiler achieve the green development, but also proves the value of itself.

ZOZEN horizontal hot oil heater

factory price industrial 4t gas boiler vietnam, ZOZEN’s YQ(Y)W series oil-fired/gas-fired vertical thermal oil heater adopts three-pass round coil structure whose end adopts conical coil which can effectively protect the furnace wall at the end of boiler. It is equipped with advanced combustion device with good energy saving and environmental protection performance. This kind of boiler has the characteristics of wide fuel adaptability, low pressure and high temperature, safety and efficiency, high thermal efficiency over 95%, and complete automatic control system which can realize unattended operation.

The front and rear smoke chamber doors of ZOZEN WNS series gas-fired (oil-fired) boilers are designed to be sleeve hinges and open like window so that it is easy to maintain, detect and clean. The special design also can get better sealing effect. Advantages: implement one-man operations.

factory price industrial 4t gas boiler vietnam, Wuxi ZOZEN Boilers Co., Ltd. takes the lead in integrating the programmable controller and touch screen in piping, electrical installation and electrical control, and applies them to the operation control of the boiler. It can realize various modern control functions such as automatic boiler control, networked device control, computer group control and remote control. The first-class hardware, practical and safe software technology ensure the fully automatic production and high-quality operation.

Meanwhile, a set of 36 tph ZOZEN DZL series biomass-fired boiler was in installation in Shandong Province. This boiler system would provide the stable heat source support for the production base of Heze Huihao Textile Co., Ltd. with an annual output of 3,000 tons of knitted fabric and 3,000 tons of rinsed knitted fabric. ZOZEN biomass-fired boiler had a reasonable primary and secondary air ratio and the SNCR intelligent denitrification device at the boiler end, which could ensure that the NOx emission concentration was less than 50mg/Nm3 to meet the environmental protection standards in Shandong Province, helping Huihao Textile realize the ultra-low NOx emission.

Moreover, ZOZEN professionals provide full guidance from the installation and the trial operation of the boiler to the training of the boiler operator, so that each user can enjoy one-stop worry-free service from pre-sales to after-sales.