industrial thermal oil boiler, In response to the restricts of natural gas supply and pipelines, ZOZEN biomass boilers are gradually recognized.

On October 15, the SZL series steam boiler project which was the first cooperation between ZOZEN Boiler and Afghanistan Baheer Group officially started to supply steam. After 24 hours of test run of the boiler, ZOZEN steam boiler burned normally, the grate ran smoothly, and the alarm devices, pressure valves and other components were also working normally. From then on, ZOZEN steam boiler would become an important member of the company’s paper production line to provide the stable and efficient steam support.

The DZL series biomass-fired horizontal three-pass water-fire tube chain grate boiler is pre-assembled boiler with a capacity of 2-20 tph (hot water boiler: 1.4-14MW) and a thermal efficiency of over 88%. By extending the furnace arch, increasing the furnace height and adjusting the width and length of grate, ZOZEN takes the lead in solving the problems that easily occur in biomass-fired boilers such as furnace arch collapse, furnace door burnout, hopper tempering and tube wall coking. It has the characteristics of wide fuel adaptability, small covering area, convenient installation and high thermal efficiency.

ZOZEN gas/oil-fired boilers adopt the large furnace design with wide fuel adaptability and sufficient fuel combustion. With the energy-saving device at the end of the flue gas duct, the boiler can improve the thermal efficiency to 98% and above. ZOZEN gas/oil-fired boilers have good energy-saving and eco-friendly effects to easily realize the ultra low NOx emission.

The header is not an independent component, but a component consisting of water-cooled walls, economizer, superheater and other components. Therefore, there are water-cooled wall header, economizer header, superheater header and so on. The function of header is to collect or distribute the steam and water working medium, reduce the transmission and connection pipes of working medium, reduce the number of drum holes, so as to improve the safety performance of drum.

Meanwhile, a set of 36 tph ZOZEN DZL series biomass-fired boiler was in installation in Shandong Province. This boiler system would provide the stable heat source support for the production base of Heze Huihao Textile Co., Ltd. with an annual output of 3,000 tons of knitted fabric and 3,000 tons of rinsed knitted fabric. ZOZEN biomass-fired boiler had a reasonable primary and secondary air ratio and the SNCR intelligent denitrification device at the boiler end, which could ensure that the NOx emission concentration was less than 50mg/Nm3 to meet the environmental protection standards in Shandong Province, helping Huihao Textile realize the ultra-low NOx emission, industrial thermal oil boiler.

The research and formulation of enterprise development strategy is a dynamic process with continuous improvement and innovation. The professional title evaluation of front-line staff means that ZOZEN’s salary system is further completed and optimized to provide a basis for the confirmation and change of staff’s salary, which reflects the company’s emphasis on talents cultivation to the greatest extent. We will strive to build ZOZEN into an excellent team with internal harmony and vitality as well as external unity and competitiveness.