ZOZEN environmental boilers provide alternative solutions for coal-fired boilers

Recently, with the convening of the NPC ( the country's top legislative body) and CPPCC (the country's top political advisory body) sessions, "Environmental Protection" has once again become a high-frequency word.

The government work report introduced that the main expected objectives of environmental protection in 2021 are to strengthen pollution prevention and ecological construction to further improve environmental quality, and continue to enhance ecological environment governance.

Environmental protection is everyone's common responsibility. In recent years, many energy equipment manufacturers in China have continuously made their own efforts for comprehensive control of air pollution. ZOZEN Boiler, a large industrial boiler manufacturer, is one of them.

ZOZEN Biomass Boiler Realizes the Comprehensive Utilization of 240,000 tons Biomass per Year

Industrial boiler is the main energy equipment in China. According to incomplete statistics, the annual coal consumption of boiler alone accounts for one third of China's raw coal output. Industrial coal-fired boilers are the main source of urban air pollution. Therefore, to achieve the environmental protection goal, it is vital to treat the coal-fired boiler with low energy efficiency and high pollution.

Based on the continuously exploration and innovation in the boiler manufacturing and project practice for more than 30 years, ZOZEN has developed the energy-saving and environment-friendly products, such as the gas-fired boiler, the biomass-fired boiler and the thermal oil heaters, which have become the alternative solutions for coal-fired boilers.

Model Project of ZOZEN Gas-Fired Thermal Oil Heater in the Chemical Industry

The coal-to-gas boiler projects completed by ZOZEN boiler, such as Jiangxi Copper Corporation, SinoPharm Yixin and Luanchuan County Thermal Energy Co., Ltd. etc., were all supported by energy-saving and environmental protection technologies, they fully matched the actual working conditions of users, realized environmental protection emissions, while reducing the operation cost.

In the central heating project of Luanchuan County, Henan Province, the application of ZOZEN SZS series gas-fired hot water boiler not only assisted Luanchuan County Thermal Energy Co., Ltd. to improve the service quality, but also vigorously promoted the clean heating work of the county. The SZS series boiler adopts the full membrane wall structure with good airtightness and sufficient heating surface. Its thermal efficiency can reach 95% and above. What’s more, ZOZEN SZS series boiler is equipped with the low-NOx burner imported from Germany, with the large-diameter furnace, the boiler can lower the NOx emission concentration to less than 30mg/Nm³, which can fully meet the requirements of clean heating.

ZOZEN Gas-fired Boiler for Luanchuan Thermal Energy Central Heating Phase I Project

The clean heating effect of ZOZEN boiler gained the recognition from the Luanchuan  Thermal Energy, local government and residents. Later, the company purchased another set of 46MW SZS series gas-fired hot water boiler, increasing the heating area from 400,000 square meters to 550,000 square meters, which would provide the sufficient and stable heat source for more residents in Luanchuan County.

ZOZEN will continue to give full play to technical advantages, promote green transformation of production and lifestyle with high-quality boilers, and continuously make contributions to the improvement of ecological environment quality.