The WNS series light diesel boiler built by ZOZEN Boiler adopt a packaged structure, which is composed of the boiler body, burner, economizer, condenser, water and steam system and control system. It has the advantages of less occupied area, convenient installation and maintenance. This time, the boiler solution customized by ZOZEN for Inversiones Goa 7 C.A. not only has sufficient output, but also has the advantages of convenient operation, environmental protection and high efficiency while meeting customers needs, and all technical indicators have reached the advanced level at home and abroad. According to the video data sent back from the customer site, ZOZEN WNS oil-fired boiler is operating very well.
ZOZEN 12 tph WNS series steam boiler is widely applied in the chemical, food, and other industries. The WNS series steam boiler is a kind of fire tube wetback boiler with a two-pass or three-pass structure. It is equipped with foreign advanced burner, economizer and condenser installed at the end of flue gas duct to lower the exhaust temperature to 60℃, achieve the thermal efficiency of over 98% and control the emission of NOx to less than 30mg/Nm3. It has the characteristics of compact structure, small covering area, short installation period, easy operation and complete automatic control system which can realize unattended operation.
In response to increasingly serious environmental problems, Ji Xiang Ju Food decides to purchase low NOx and eco-friendly gas-fired steam boiler. To meet the new requirements, ZOZEN Boiler customizes the boiler system and recommends SZS series low NOx steam boiler to ensure the sufficient heat supply for Ji Xiang Ju Food's production line. This series of gas-fired boiler adopts D-model full membrane wall structure and combustion chamber adopts narrow-spacing tube membrane wall with good air impermeability to reduce heat loss and enhance the thermal efficiency to 98% and above with the economizer at the end of flue gas duct.
Bolivia is the highest average altitude country in the world, local Bolivian companies have higher requirements for boilers than general boilers. As the altitude increases, the atmospheric pressure and the air density decrease accordingly, which adversely affects boiler combustion.
In view of this situation, ZOZEN technical team makes adjustments from the combustion system and exhaust system of boiler, fully considering the influence of low air pressure on boiler body design and combustion. By appropriately increasing the volume of the furnace to extend the residence time of the fuel in the furnace, and the problems of slow fuel burning speed and long burning time are solved.
SZL series vertical dual drums chain grate water tube steam and hot water boiler, adopts quick fitting and assembly structure. The 4-6t/h boiler is of quick fitting tube structure, exit shop after completely assembled, the boiler of 6-35t/h is composed of 2 main components. The upper assembled component is the boiler proper heat absorbing part, and the lower assembled component is of combustion equipment. The former part of the boiler proper is arranged a membrane wall, the upper part of it is connected to boiler cylinder, and its lower part is connected to collective chest, so as to form a combustion room and absorb the radiated heat from the furnace. Its rear part is arranged with dense convection tubes between upper and lower boiler cylinders. The high temperature smog after combustion shall stand for twice returning flushing transversely to the heat accepting surfaces, and shall be introduced to coal saver singly arranged, and flow into duster and exhausted from chimney in the end.
The production processes of textiles such as drying, shaping, printing, etc require stable heat source support. WNS series gas-fired steam boilers feature fully automatic and safe operation to ensure the stability of the heat source during the production process. At the same time, the gas-fired boiler has remarkable energy-saving and environmental protection effects, the thermal efficiency can reach over 98%, and the NOx emission can be as low as 30 mg/m³, which fully meets the needs of the environmental protection era.
