According to the specific conditions of the pulp and paper industry, ZOZEN boiler provides boilers with high combustion efficiency and low operating cost and is recognized by paper enterprises. The advanced boiler automatic controller, man-machine interface, users only need to set easily, the boiler can start and stop, regulate load and according to user requirements, load regulation, automatic water supply and other fully automatic operation.
ZOZEN DZL series boiler can use both biomass and coal as fuel. The dual fuel adaptability would help users to save fuel costs. It adopts three-pass water and fire tube design and can be equipped with economizer and duster cleaner to ensure the combustion efficiency, which can effectively lower the NOx emission. Please kindly click the chat online to get more information.
The packaged structure is another characteristic of ZOZEN boiler. After the gas/oil-fired thermal oil heater is delivered to the project site, it can be put into use only by connecting the gas/oil, electricity, which can save a lot of installation costs. What's more, the boiler has the patented equipment to completely remove the moisture from the thermal oil heater after the hydraulic pressure test and reduce the oil dewatering time. Take the 6 million kcal as an example, it usually takes 10 days for oil dewatering while ZOZEN only needs 2 days, which reduces the 80% time for dewatering and directly save the costs for about 30,000 RMB.
This is ZOZEN thermal oil heater adopts the multi-circuit coil design with sufficient heating surface and good heat transfer effect which effectively protect the burner and furnace wall. The boiler adopts high-quality refractory and thermal insulation materials which can well reduce the heat loss based on the different refractory and thermal insulation structure for areas with different temperatures. In addition, based on the actual conditions, we also add the waste heat boiler, economizer, air pre-heater and other energy-saving equipment to make exhaust gas temperature to less than 90℃ and the thermal efficiency to reach over 95% and to help the enterprise reduce consumption and the costs.
The new generation of SZL series boiler is cooperated with Shanghai Jiaotong University. It increases the furnace height, increases rotating speed, adds ash blowing device and designs ash removal system at the bottom of the grate. These well solve problems like scaling, abrasion, front arch, etc. It can also reduce the maintenance and operating costs and extend the service life of the biomass-fired boilers.
Binzhou Xinkeode Technology Co., Ltd. is a private enterprise engaged in the production and sales of neopentyl glycol, sodium formate and formaldehyde. According to the actual situation of Xinkeode’s production lines, ZOZEN Boiler recommended the SZS series gas-fired condensing boiler. This series of steam boiler adopts the large furnace design and advanced burner, which can ensure the sufficient combustion of fuel to improve the fuel use ratio. With the energy-saving equipment at the end of the gas duct, the boiler thermal efficiency can reach 98% and above to save the operating costs.
ZOZEN SZL series biomass-fired boiler has the characteristics of sufficient output and high thermal efficiency. To ensure the sufficient combustion of fuel and save the fuel costs, ZOZEN analyzes the characteristics of different fuels, and optimizes the feeding hopper, width and length of grate, grate rotating speed, secondary air inlet place and direction. ZOZEN also adopts the design of separate air chambers and air dampers to ensure the complete combustion of different biomass fuels and improve the boiler thermal efficiency to above 88%.
DZL series hot water boiler is horizontal three-pass water-fire tube chain grate boiler. It uses fuel like coal and biomass pellets. The thread smoke tubes inside the drum form the convention heating surface while the drum and two-side water-cooled wall form the furnace radiation heating surface. Its boiler structure is compact. It can be packaged before shipment which can reduce the costs of basic boiler construction. Therefore, it is a kind of popular heating equipment among hotels, schools and hospitals.
