According to the specific conditions of the pulp and paper industry, ZOZEN boiler provides boilers with high combustion efficiency and low operating cost and is recognized by paper enterprises. The advanced boiler automatic controller, man-machine interface, users only need to set easily, the boiler can start and stop, regulate load and according to user requirements, load regulation, automatic water supply and other fully automatic operation.
Among many boiler types, biomass-fired chain grate boiler has the advantages of wide fuel adaptability, low original emission concentration, low operating costs and easy operation. Based on the eco-friendly development thinking, ZOZEN Boiler has long been designing and manufacturing the chain grate boilers. At present, the DZL series industrial boiler adopts the advanced arch design, independently developed membrane water-cooled wall structure, special slag removal technology and reasonable sealing grate structure, which shows an obvious performance advantage.
This is ZOZEN thermal oil heater adopts the multi-circuit coil design with sufficient heating surface and good heat transfer effect which effectively protect the burner and furnace wall. The boiler adopts high-quality refractory and thermal insulation materials which can well reduce the heat loss based on the different refractory and thermal insulation structure for areas with different temperatures. In addition, based on the actual conditions, we also add the waste heat boiler, economizer, air pre-heater and other energy-saving equipment to make exhaust gas temperature to less than 90℃ and the thermal efficiency to reach over 95% and to help the enterprise reduce consumption and the costs.
The new generation of SZL series boiler is cooperated with Shanghai Jiaotong University. It increases the furnace height, increases rotating speed, adds ash blowing device and designs ash removal system at the bottom of the grate. These well solve problems like scaling, abrasion, front arch, etc. It can also reduce the maintenance and operating costs and extend the service life of the biomass-fired boilers.
ZOZEN SZL series biomass-fired boiler has the characteristics of sufficient output and high thermal efficiency. To ensure the sufficient combustion of fuel and save the fuel costs, ZOZEN analyzes the characteristics of different fuels, and optimizes the feeding hopper, width and length of grate, grate rotating speed, secondary air inlet place and direction. ZOZEN also adopts the design of separate air chambers and air dampers to ensure the complete combustion of different biomass fuels and improve the boiler thermal efficiency to above 88%.
ZOZEN SZL series biomass-fired boiler can be fired by various kinds of fuel including biomass particles, wood chips, palm shells, straws and so on. The boiler body is composed of the chain grate and boiler proper with a packaged or pre-assembled structure. It is convenient for installation, so it can reduce the basic construction costs for customers. At the same time, in order to meet the boiler emission standards in different areas, ZOZEN Boiler can design the cyclone, wet scrubber and bag-type dust removal devices to lower the NOx emission to 200mg/m3.
DZL series hot water boiler is horizontal three-pass water-fire tube chain grate boiler. It uses fuel like coal and biomass pellets. The thread smoke tubes inside the drum form the convention heating surface while the drum and two-side water-cooled wall form the furnace radiation heating surface. Its boiler structure is compact. It can be packaged before shipment which can reduce the costs of basic boiler construction. Therefore, it is a kind of popular heating equipment among hotels, schools and hospitals.
WNS series gas-fired or oil-fired hot water boiler is smoke-fire tube chamber combustion boiler and adopts two-pass or three-pass structure. It also adopts large-diameter waveform stove furnace with good thermal expansion and safety performance. There are condenser and economizer added at the end of flue gas duct which can improve the thermal efficiency to more than 95% and save boiler's operation costs.
