Among many boiler types, biomass-fired chain grate boiler has the advantages of wide fuel adaptability, low original emission concentration, low operating costs and easy operation. Based on the eco-friendly development thinking, ZOZEN Boiler has long been designing and manufacturing the chain grate boilers. At present, the DZL series industrial boiler adopts the advanced arch design, independently developed membrane water-cooled wall structure, special slag removal technology and reasonable sealing grate structure, which shows an obvious performance advantage.
The packaged structure is another characteristic of ZOZEN boiler. After the gas/oil-fired thermal oil heater is delivered to the project site, it can be put into use only by connecting the gas/oil, electricity, which can save a lot of installation costs. What's more, the boiler has the patented equipment to completely remove the moisture from the thermal oil heater after the hydraulic pressure test and reduce the oil dewatering time. Take the 6 million kcal as an example, it usually takes 10 days for oil dewatering while ZOZEN only needs 2 days, which reduces the 80% time for dewatering and directly save the costs for about 30,000 RMB.
The new generation of SZL series boiler is cooperated with Shanghai Jiaotong University. It increases the furnace height, increases rotating speed, adds ash blowing device and designs ash removal system at the bottom of the grate. These well solve problems like scaling, abrasion, front arch, etc. It can also reduce the maintenance and operating costs and extend the service life of the biomass-fired boilers.
ZOZEN SZL series biomass-fired boiler has the characteristics of sufficient output and high thermal efficiency. To ensure the sufficient combustion of fuel and save the fuel costs, ZOZEN analyzes the characteristics of different fuels, and optimizes the feeding hopper, width and length of grate, grate rotating speed, secondary air inlet place and direction. ZOZEN also adopts the design of separate air chambers and air dampers to ensure the complete combustion of different biomass fuels and improve the boiler thermal efficiency to above 88%.
ZOZEN SZL series biomass-fired boiler can be fired by various kinds of fuel including biomass particles, wood chips, palm shells, straws and so on. The boiler body is composed of the chain grate and boiler proper with a packaged or pre-assembled structure. It is convenient for installation, so it can reduce the basic construction costs for customers. At the same time, in order to meet the boiler emission standards in different areas, ZOZEN Boiler can design the cyclone, wet scrubber and bag-type dust removal devices to lower the NOx emission to 200mg/m3.
WNS series gas-fired or oil-fired hot water boiler is smoke-fire tube chamber combustion boiler and adopts two-pass or three-pass structure. It also adopts large-diameter waveform stove furnace with good thermal expansion and safety performance. There are condenser and economizer added at the end of flue gas duct which can improve the thermal efficiency to more than 95% and save boiler's operation costs.
