35-ton gas-fired boiler, ZOZEN Boiler recommends SZS series gas-fired boiler. SZS series 35 tons gas-fired boiler adopts membrane wall with narrow spacing in its combustion chamber, which not only increases the heating surface of the main body, but also improves the air tightness and reduces the heat loss. The thermal efficiency of the boiler is over 98%.
WNS series and SZS series gas-fired steam/hot water boilers are the best-selling products of ZOZEN Boiler, which have the advantages of high thermal efficiency over 98%, emission of nitrogen oxides below 30mg/nm, excellent energy saving and environmental protection performance, and are well received by domestic and foreign markets. The capacity range of ZOZEN gas-fired steam/hot water boiler is 1-110 t/h and 0.7-116 MW, which can meet various production and heating needs of enterprises.
ZOZEN SZS series gas/oil-fired boiler adopts the PLC control system, it can automatically control the system by temperature, water level and pressure control. ZOZEN Boiler provides the advanced parts and auxiliaries with the boiler system.
ZOZEN Boiler has cooperated with the Department of Thermal Engineering of Shanghai Jiaotong University to jointly develop the DZL series tri-drum biomass-fired boiler. This kind of steam boiler is a water tube boiler adopting the assembled structure with two parts. The boiler can be equipped with different grates to ensure the sufficient combustion of biomass fuels.
Among many boiler types, biomass-fired chain grate boiler has the advantages of wide fuel adaptability, low original emission concentration, low operating costs and easy operation. Based on the eco-friendly development thinking, ZOZEN Boiler has long been designing and manufacturing the chain grate boilers. At present, the DZL series industrial boiler adopts the advanced arch design, independently developed membrane water-cooled wall structure, special slag removal technology and reasonable sealing grate structure, which shows an obvious performance advantage.
The packaged structure is another characteristic of ZOZEN boiler. After the gas/oil-fired thermal oil heater is delivered to the project site, it can be put into use only by connecting the gas/oil, electricity, which can save a lot of installation costs. What's more, the boiler has the patented equipment to completely remove the moisture from the thermal oil heater after the hydraulic pressure test and reduce the oil dewatering time. Take the 6 million kcal as an example, it usually takes 10 days for oil dewatering while ZOZEN only needs 2 days, which reduces the 80% time for dewatering and directly save the costs for about 30,000 RMB.
DZL series hot water boiler is horizontal three-pass water-fire tube chain grate boiler. It uses fuel like coal and biomass pellets. The thread smoke tubes inside the drum form the convention heating surface while the drum and two-side water-cooled wall form the furnace radiation heating surface. Its boiler structure is compact. It can be packaged before shipment which can reduce the costs of basic boiler construction. Therefore, it is a kind of popular heating equipment among hotels, schools and hospitals.
WNS series gas-fired or oil-fired hot water boiler is smoke-fire tube chamber combustion boiler and adopts two-pass or three-pass structure. It also adopts large-diameter waveform stove furnace with good thermal expansion and safety performance. There are condenser and economizer added at the end of flue gas duct which can improve the thermal efficiency to more than 95% and save boiler's operation costs.
