boiler gas conversion burner, ZOZEN boiler has higher cost-efficiency than other boiler manufacturers

boiler gas conversion burner, Innovation is an inexhaustible driving force for enterprise development. The main products of ZOZEN Boiler include gas-fired/oil-fired boilers, coal-fired boilers, biomass-fired boilers, thermal oil heaters with over 400 kinds, which are widely applied in electronics, building materials, construction, food, tobacco, chemical, metallurgy, paper and other industries. ZOZEN Boiler regards product quality as the life of enterprise. ZOZEN boiler’s main components and wear parts adopt advanced processing technology which makes the equipment wear-resisting. Therefore, ZOZEN boilers have a good reputation at home and abroad and are exported to Russia, Kazakhstan, South Africa, Egypt, Vietnam, Malaysia, Australia and other countries and regions.

With years of efforts, ZOZEN has obtained outstanding achievements in the overseas market. Recently, ZOZEN participated in a large photovoltaic industrial chain project in Turkey, which showed that the brand and strength of ZOZEN were recognized by the overseas market.With an annual output of 500MW, the photovoltaic industrial chain project in Turkey is a key project of the Belt and Road China-Turkey cooperation project. On December 12, the opening ceremony of the project was held at the Başkent OIZ Industrial Park in Ankara.

The WNS series oil-fired/gas-fired boiler is a kind of fire tube wetback boiler with a two-pass or three-pass structure. It is equipped with foreign advanced burner, economizer and condenser installed at the end of flue gas duct to lower the exhaust temperature to 60℃, achieve the thermal efficiency of over 98% and control the emission of NOx to less than 30mg/Nm3. It has the characteristics of compact structure, small covering area, short installation period, easy operation and complete automatic control system which can realize unattended operation.

ZOZEN biomass-fired boilers refer to the boilers fueled by biomass energy, which are typically energy-saving and eco-friendly products. Biomass fuel usually refers to the agricultural and forestry wastes such as various crop straws, leaves, wood chips and so on, which are renewable and recyclable. The operating cost of biomass-fired boilers is low, which is only a half of that of gas-fired boilers. However, the initial investment cost of biomass-fired boilers is higher than that of oil-fired or natural gas fired boilers. Biomass-fired boilers are good alternatives to gas-fired boilers when replacing the coal-fired boilers. At present, the technical parameters of biomass-fired boilers are 2-75 tph (rated capacity) and 2.0-116 MW (rated thermal power).

boiler gas conversion burner, The smoke chamber is an important part of the horizontal boiler and selects heat preservation and refractory materials with high performance. It adopts the double-layer aluminum foil for heat preservation to greatly enhance the insulation effect. The front and back smoke chambers adopt the special double-sealed structure to solve the smoke leakage problem which is common during the long-term operation of horizontal internal combustion boiler, so as to reduce the heat loss caused by smoke leakage; meanwhile, it also adopts the double-door structure with reliable performance and good tightness to ensure the safe and reliable boiler operation.

boiler gas conversion burner, Recently, ZOZEN successfully became the boiler supplier of the textile giant in Pakistan Kay & Emms (Pvt) Ltd and provided 5 million cal YLW series coal fired chain grate thermal oil heater for the company. The oil heater can provide high-temperature heat source at various temperatures below 350℃, achieving low-pressure and high-temperature heating for the processes of dyeing, drying, slashing, printing and dyeing, etc.

All boilers are subject to damage if proper water treatment procedures are not followed. This is an important consideration both during operation and when the boiler is idle. To avoid damage and costly repairs, monitor water chemistry routinely and ensure that you are supplying your boiler with soft water at all times.