Continuing the 2020 industrial live streaming mode, ZOZEN Boiler has made the online visit normal. Recently, at the modern production base of Wuxi ZOZEN Boiler, technicians had connected with Finnish customers via the live streaming to show the whole process of the boiler hydrostatic test. Through the live streaming, ZOZEN not only showed the entire panorama of the hydrostatic test, but also showed the operating steps and pressure gauge values on the top of the boiler. The customers were very satisfied.
ZOZEN WNS series gas-fired steam boiler adopts the large-diameter corrugated furnace and threaded smoke tube to increase the heating surface, reduce the thermal stress and improve the boiler's safety performance; meanwhile, in order to reduce the heat loss caused by gas exhaust and operating costs, ZOZEN also adds energy-saving devices at the end of the flue gas duct to improve the thermal efficiency to over 98%. In addition, the two sets of boilers also meet the ASME standards, which proves that ZOZEN product quality is up to international standards.
ZOZEN DZL series packaged boiler is horizontal three-pass water and fire tube chain grate boiler with a wide fuel adaptability to biomass particles, bituminous coal, meagre coal and anthracite. The boiler proper is a longitudinal single drum. The threaded smoke tubes in the drum form the convention heating surface. The drum and water-cooled walls on both sides form the radiation heating surface in the furnace. The combustion equipment adopts the light chain grate. The boiler is reasonably arranged with primary air and secondary air, and is equipped with economizer and dust collector at the boiler end to control the NOx emission concentration below 200mg/m3. Meanwhile, the boiler realizes the stepless speed regulation of the grate via the electric control. There are also the absolute rating alarm and interlocking protection functions to make the boiler safer. It is widely used in the chemical, food, tobacco, textile, printing and dyeing, feed, medicine and building materials industries.
ZOZEN WNS series gas-fired and oil-fired boiler is equipped with the advanced condenser, which is a kind of flue gas waste heat exchanger whose working principle is the same as the economizer at the end of the coal-fired boiler. After a condenser is installed at the end of the boiler's flue gas duct, the high-temperature flue gas passes through the flue gas duct and the condenser at the same time, which can heat the water in the condenser, increase the feed water temperature and lower the exhaust gas temperature to achieve the goals of saving fuel and improving the thermal efficiency.
A set of industrial boiler with sufficient output and stable heating supply can directly affect the daily production of a food company. ZOZEN DZL series biomass-fired steam boiler adopts the single-drum longitudinal layout and chain grate stratified combustion method. ZOZEN technicians has optimized the design of the feed hopper, grate width and length, speed of grate reducer and position of secondary air outlet by analyzing the different fuel characteristics and practical use requirements of customers to ensure the sufficient combustion of biomass pellets and improve the combustion efficiency. Meanwhile, DZL series biomass fired steam boiler adopts the thread smoke tubes developed by ZOZEN to strengthen the heat transfer and improve the thermal efficiency. The heat transfer coefficient of thread smoke tube is 1.8 times higher than that of ordinary smoke tube and the thermal efficiency of boiler is over 88%, which can fully meet the daily production demands of enterprises.
Thermal oil heaters, also known as organic heat carrier boilers, adopt the organic heat carrier as heat medium to realize heat transfer. Due to the high temperature characteristics of organic heat carrier, thermal oil heaters can realize low-pressure and high-temperature heating with an oil output temperature of 350℃. Thermal oil heaters adopt injection-type forced circulation system and heat exchange surface adopts round and square coil structures, which also have a wide fuel adaptability of oil, gas, coal, biomass. ZOZEN Boiler, as a leader in the boiler industry, has improved and upgraded its YQW series, YQL series and YLW series thermal oil heaters applied in the chemical industry to meet the production demands of chemical enterprises. They are equipped with complete operation control and safety monitoring devices which can precisely control the working temperature to ensure boiler's safe operation. They are popular among and favored by chemical enterprises.
ZOZEN guides and cultivates different kinds of talents according to their different characteristics and laws of growth. In late July, ZOZEN Boiler launched a three-day job training program for new graduates, which was held by the vice general manager and boiler designer, Zhu Qiuping. As a senior boiler engineer, vice general manager Zhu has more than 30 years of experience in boiler design, especially in designing large-scale circulating fluidized bed boiler and gas-fired boiler. He is now the head in charge of ZOZEN Boiler's R&D and design department and is one of the representative persons of ZOZEN Boiler's "soft power".
Recently, ZOZEN Boiler has organized the training about boiler manufacturing process. This training is given by ZOZEN Boiler's sales manager with the participation of new employees from e-commerce department. They listens carefully and sales manger answers questions for them. The training is relaxing and pleasant, which improves their teamwork ability, deepens their mutual understanding and establishes a friendly and happy working relationship between them.
