An air preheater is used to preheat the fuel which further increases the boiler efficiency. It is designed to heat air before another process by extracting the waste heat from the flue gases leaving the boiler to effectively reduce the flue gas temperature and improve the thermal efficiency.
WNS series horizontal internal combustion boiler is a boiler shell type 3 passes wetback oil/gas fired boiler. After fuel is being atomized by burner, flame is full of the wave furnace and transfer heat via furnace wall, this is 1st pass; the high temperature smoke is collected in reversal chamber and then enters 2nd pass which is grooved tubes bundle area; after heat convection, air temperature gradually falls and goes to front smoke box and turn to 3rd pass, which is smooth tubes bundle area, and then enters chimney passing back smoke box and exhausted to the atmosphere.
ZOZEN DZL series biomass/coal-fired boiler has designed with multiple separate air chambers, which can realize the air distribution at different combustion. With the speed gear, the sufficient combustion of fuel can be ensured according to different combustion rate.
In 2020, ZOZEN Boiler successfully supplied boilers in Venezuela, Thailand, Afghanistan, Karachi, Zimbabwe and many other countries. Especially in Afghanistan, ZOZEN provided one set of SZL series coal-fired steam boiler for Baheer Group, providing heat source for the paper production line. It successfully passed the environmental protection inspection organized by Afghan government, which had been proved to meet the local environmental protection standards due to the high combustion efficiency and super-clean flue gas emissions.
Continuing the 2020 industrial live streaming mode, ZOZEN Boiler has made the online visit normal. Recently, at the modern production base of Wuxi ZOZEN Boiler, technicians had connected with Finnish customers via the live streaming to show the whole process of the boiler hydrostatic test. Through the live streaming, ZOZEN not only showed the entire panorama of the hydrostatic test, but also showed the operating steps and pressure gauge values on the top of the boiler. The customers were very satisfied.
Among many boiler types, biomass-fired chain grate boiler has the advantages of wide fuel adaptability, low original emission concentration, low operating costs and easy operation. Based on the eco-friendly development thinking, ZOZEN Boiler has long been designing and manufacturing the chain grate boilers. At present, the DZL series industrial boiler adopts the advanced arch design, independently developed membrane water-cooled wall structure, special slag removal technology and reasonable sealing grate structure, which shows an obvious performance advantage.
In Sri Lanka, a set of ZOZEN 15 tph DZW series biomass-fired steam boiler was being installed and debugged. The user is a well-known local palm oil manufacturer, AEN PALM OIL PROCESSING (PVT) LTD. The boiler fuel is palm fiber. The boiler is a tri-drum boiler which has characteristics of no ash accumulation, high efficiency and good environmental protection performance. There is no need to stop the boiler for dust removal, which can make the boiler keep the normal operation for a long time. Meanwhile, considering the combustion characteristics of palm fiber, ZOZEN technicians also optimize the feeding hopper, furnace arch and air distribution device of the boiler to solve the coking problem caused by the fuel combustion.
The new generation of SZL series boiler is cooperated with Shanghai Jiaotong University. It increases the furnace height, increases rotating speed, adds ash blowing device and designs ash removal system at the bottom of the grate. These well solve problems like scaling, abrasion, front arch, etc. It can also reduce the maintenance and operating costs and extend the service life of the biomass-fired boilers.
