ZOZEN Boiler is good at designing different boiler systems and accessories according to different boiler room areas. This group of pictures shows the boiler condenser specially designed by ZOZEN Boiler, which is installed at the end of the boiler flue. The working principle is to use the waste heat in the boiler flue gas to heat the boiler feed water, which effectively reduces the heat loss and improves the thermal efficiency of the boiler system.
ZOZEN DZL series packaged boiler is horizontal three-pass water and fire tube chain grate boiler with a wide fuel adaptability to biomass particles, bituminous coal, meagre coal and anthracite. The boiler proper is a longitudinal single drum. The threaded smoke tubes in the drum form the convention heating surface. The drum and water-cooled walls on both sides form the radiation heating surface in the furnace. The combustion equipment adopts the light chain grate. The boiler is reasonably arranged with primary air and secondary air, and is equipped with economizer and dust collector at the boiler end to control the NOx emission concentration below 200mg/m3. Meanwhile, the boiler realizes the stepless speed regulation of the grate via the electric control. There are also the absolute rating alarm and interlocking protection functions to make the boiler safer. It is widely used in the chemical, food, tobacco, textile, printing and dyeing, feed, medicine and building materials industries.
ZOZEN WNS series gas-fired and oil-fired boiler is equipped with the advanced condenser, which is a kind of flue gas waste heat exchanger whose working principle is the same as the economizer at the end of the coal-fired boiler. After a condenser is installed at the end of the boiler's flue gas duct, the high-temperature flue gas passes through the flue gas duct and the condenser at the same time, which can heat the water in the condenser, increase the feed water temperature and lower the exhaust gas temperature to achieve the goals of saving fuel and improving the thermal efficiency.
CMU short for China Medical University, located in Shenyang, Liaoning, is a university jointly established by the National Health and Family Planning Commission, the Ministry of Education, and the Liaoning Provincial Government. The DHL series hot water boiler provided by ZOZEN is the second-generation corner tube hot water boiler. This return visit, ZOZEN carried out all-round maintenance for the boiler to ensure the safety and stability of its heating in this winter.
Shenyang Third Thermal Heating Co., Ltd. is one of the largest companies of the central heating industry in Shenyang. The body and the middle partition wall of ZOZEN DHL series corner tube hot water boiler adopt membrane water wall complete sealing structure, which greatly reduces the boiler heat loss and improves the boiler thermal efficiency. Meanwhile, the flag heating surface of this series of boilers is designed with patented technology of the same smoke velocity in variable cross-section, so that the flow velocity of the smoke in heated surface between the high temperature zone and the low temperature zone is uniform, reducing the ash accumulation and increasing the heat transfer co-efficiency.
SZS series boiler is designed with longitudinal double drums and " D " type chamber structure. Furnace is placed on the right and convection tube bank is on the left, super heater is arranged at convection tube bank. The body is fixed on the basement by middle and both end flexible supports and make the boiler expand horizontally sideways. Around the furnace is membrane water cooling tube wall. Furnace and tube bank are totally separated by the membrane water tube cooling wall at the left side of the furnace. The back part of bundle is sparse shift structure, front part is aligned structure. Smoke from furnace outlet enters re-burning chamber, convection tube bank area and then from left front part enters spiral fine coil economizer and condenser, and finally is discharged to atmosphere through chimney.
