foam system for boilers, ZOZEN boiler reasonably designs different flue air systems according to customer requirements

foam system for boilers, In the comprehensive office building of ZOZEN Boiler, Design Department, Technology Department, Production Department, Quality Inspection Department and Marketing Department coordinate with each other to promote the projects in a smooth and quick way. In the modern multifunctional meeting room, there is a lot of domestic and international certification acquired by ZOZEN including the A-grade boiler and BRⅡ-grade pressure container manufacturing licence, ASME “S” (utility boiler), “U” (pressure container) steel seal licence of USA and ISO9001 international quality system certification.

Jindal Group is a world-renowned manufacturer and supplier of steel pipe products and fittings. With the expansion of its sales network, Jindal is preparing to build a ductile iron pipe production plant in Abu Dhabi, UAE. Boiler, as the thermal energy equipment of the factory, is an indispensable part in the construction of the factory area. The person in charge of Jindal immediately contacted ZOZEN. Considering that the United Arab Emirates is rich in natural gas resources, ZOZEN recommended  its energy-saving and environmentally friendly WNS series gas boilers for Jindal.

ZOZEN’s YQ(Y)W series oil-fired/gas-fired vertical thermal oil heater adopts three-pass round coil structure whose end adopts conical coil which can effectively protect the furnace wall at the end of boiler. It is equipped with advanced combustion device with good energy saving and environmental protection performance. This kind of boiler has the characteristics of wide fuel adaptability, low pressure and high temperature, safety and efficiency, high thermal efficiency over 95%, and complete automatic control system which can realize unattended operation.

ZOZEN’s YLW series coal-fired/biomass-fired thermal oil heater has wide fuel adaptability to various kinds of coal and biomass. The boiler’s heat exchange surface adopts square coil structure with more sufficient heating surface and higher thermal efficiency. With the flue gas waste heat system, the thermal efficiency can reach to 85%. Meanwhile, advanced measurement and control systems of oil temperature, smoke temperature and oil pressure can ensure the long-time and stable operation of the thermal oil heater. ZOZEN has successfully provided the stable heat source for the forming and drying processes in the production of laundry soap, bath soap and other products of Azhar Corporation (Pvt) Ltd..

ZOZEN WNS series gas fired boiler not only adopts advanced low NOx burners. And through the flue gas recirculation technology, about 10% -30% of the flue gas at the tail of the boiler is sucked into the air inlet of the burner through the flue gas pipe, mixed with the combustion-supporting air, and then entering the furnace, thereby reducing the temperature and oxygen concentration in the combustion area, and finally reducing The amount of thermal NOx is generated, and the NOx in the tail gas of the boiler are less than 30mg/Nm3, which meets the requirements of low nitrogen emissions of the enterprise.enterprise, foam system for boilers.

ZOZEN has set up a total of seven process stopping points throughout the production process, which are strictly controlled by different engineers, independent of each other and supervised each other, so that problems can be found and solved in time. If any workpiece is unqualified, it cannot enter the next process, which is the quality control of the entire production process of ZOZEN.

ZOZEN will always adhere to technology research and development, and continue to provide efficient and energy-saving boiler systems for enterprises, further contributing to the high-quality development of the domestic fine chemical industry, foam system for boilers.