commercial 20 ton coal boiler cheap indonesia, industrial boiler manufacturer ZOZEN boiler comprehensively analyzes the low nox principle of natural gas boilers

ZOZEN Boiler (Wuxi) is located along the coast of the beautiful Taihu Lake. It covers an area of 120,000 square meters and has a registered capital of 127 million yuan. It is an AAA credit rating enterprise and a high-tech enterprise in Jiangsu Province; and it has an annual production capacity of 2,000 industrial boilers and 25,000 tons of steam.

Recently, as a leading enterprise in the domestic industrial boiler manufacturing industry, ZOZEN has successfully passed the examination of Jiangsu Market Supervision and Administration Bureau and has acquired the permission to engage in the installation, maintenance and reconstruction project of pressure-bearing special equipment with a sub project of boiler installation (A grade), which is valid until the August 7, 2024.

commercial 20 ton coal boiler cheap indonesia, ZOZEN YLW series thermal oil heater is a kind of horizontal square-coil chain grate boiler. It is pre-assembled, so the chain grate and boiler proper are separated for shipment. The boiler adopts the chain grate for mechanical coal feeding, the forced and induced draft fans for mechanical ventilation and the slag discharger for mechanical slag discharge. During operation, the fuel falls from the coal hopper onto the grate for combustion. The high-temperature flue gas is reflected from the back arch to the front of the furnace and enters the furnace. After the radiant heat exchange, it enters the convective heating surface for convective heat exchange and then goes to the waste heat boiler, air preheater and dust collector. Finally, the flue gas is drawn by the induced draft fan through the chimney and is discharged into the atmosphere.

ZOZEN circulating fluidized bed boiler adopts the low-temperature fluidized combustion technology, which is a new and mature clean technology with low pollution. The circulating fluidized bed boiler can realize low-NOx emission at no cost by itself and the direct desulfurization during the combustion process to solve the SO2 and NOx emission problems. The direct desulfurization in the furnace is relatively simple and lower in cost compared with the flue gas purification technology at the boiler end.

commercial 20 ton coal boiler cheap indonesia, As a professional industrial boiler manufacturer, Wuxi ZOZEN Boilers Co., Ltd. pays attention to quality and adheres to the spirit of craftsmanship to guarantee the quality of boiler products through a complete quality assurance system. In 2020, ZOZEN Boiler regards quality management as one of the key breakthroughs of corporate development, and adopts a series of powerful reform measures to enhance the quality awareness of all employees and the quality of corporate development.

In September, ZOZEN SZL series biomass-fired boiler provided for Inner Mongolia Jinshan Mining had been debugged and put into operation smoothly. The boiler has a higher furnace and reasonable grate rotate speed to ensure the sufficient fuel combustion and improve the thermal efficiency to 88% and above. At the same time, the boiler convention area is also equipped with an ash removal device independently developed by ZOZEN which not only has good tightness, but also greatly reduces the workload of the boiler operation and maintenance personnel, so as to help Jinshan Mining achieve clean production and build a green mine.

ZOZEN Boiler has always invested a lot in the research and development of the environmentally friendly industrial boilers with the long-term strategy and firm determination to bravely move forward on the road of green and sustainable development.