3 ton oil fired boiler for sale, the advanced manufacturing process of ZOZEN automatic gas-fired boilers has triggered the concerns of the rubber industry

Improper water treatment is the leading cause of tube damage and poor performance in a boiler system. In this month, ZOZEN will discuss the consequences of introducing your boiler to hard water and the importance of utilizing a water softener.

On November 14, a large-scale environmental protection inspection of coal-fired boilers was carried out locally in Afghanistan, and a large number of factories that did not meet environmental protection standards were closed. At the same time, the SZL series of coal-fired boiler customized by ZOZEN Boiler for Baheer Group passed the environmental protection inspection because of its sufficient output, high combustion efficiency and ultra-clean flue gas emission.

ZOZEN YLW series thermal oil heater is of square coil tube vertical type chain grate, it consists of two separate parts - chain grate stoker and heater body. After erection on site, it only needs to connect to thermal oil piping and electricity to start operation. The heater adopts chain grate to perform mechanical fuel feeding, equipped with FD fan and ID fan for air ventilation, and also equipped with slay discharger to remove the bottom slag, 3 ton oil fired boiler for sale.

3 ton oil fired boiler for sale, ZOZEN biomass-fired boilers refer to the boilers fueled by biomass energy, which are typically energy-saving and eco-friendly products. Biomass fuel usually refers to the agricultural and forestry wastes such as various crop straws, leaves, wood chips and so on, which are renewable and recyclable. The operating cost of biomass-fired boilers is low, which is only a half of that of gas-fired boilers. However, the initial investment cost of biomass-fired boilers is higher than that of oil-fired or natural gas fired boilers. Biomass-fired boilers are good alternatives to gas-fired boilers when replacing the coal-fired boilers. At present, the technical parameters of biomass-fired boilers are 2-75 tph (rated capacity) and 2.0-116 MW (rated thermal power).

ZOZEN has set up a total of seven process stopping points throughout the production process, which are strictly controlled by different engineers, independent of each other and supervised each other, so that problems can be found and solved in time. If any workpiece is unqualified, it cannot enter the next process, which is the quality control of the entire production process of ZOZEN.

In September, ZOZEN SZL series biomass-fired boiler provided for Inner Mongolia Jinshan Mining had been debugged and put into operation smoothly. The boiler has a higher furnace and reasonable grate rotate speed to ensure the sufficient fuel combustion and improve the thermal efficiency to 88% and above. At the same time, the boiler convention area is also equipped with an ash removal device independently developed by ZOZEN which not only has good tightness, but also greatly reduces the workload of the boiler operation and maintenance personnel, so as to help Jinshan Mining achieve clean production and build a green mine.

Industrial boiler belongs to special equipment and has high requirements for product safety factors. As the domestic well-known boiler supplier, ZOZEN has advanced mechanical equipment, mature manufacturing process and guarantee of boiler quality. In addition, via the innovation and development of ZOZEN’s professional design team, the structure and material of boiler proper are continuously improved and optimized to greatly extend boiler’s service life. It is also worth mentioning that ZOZEN’s automatic boiler control system with dozen kinds of safety protection interlocks can fully ensure boiler’s safety. In the aspect of environmental protection performance, ZOZEN boilers are also outstanding. The flue gas emission of ZOZEN boilers nearly meets the EU standards. The NOx emission is low to 30mg, which realizes the goal of low-nitrogen emission.