how long does coal fired tube boiler last, ZOZEN circulating fluidized bed boiler is committed to the clean utilization of coal resources

Due to continued success and growth, ZOZEN Boilers introduces a new team to support its strategic vision to deliver more efficient, innovative and sustainable products and services.

During the processing of broilers, whether it is retort sterilization, baking and cooking, or heating and drying, the heat source provided by the steam boiler is required. ZOZEN successfully won the full recognition of the Chia Tai Group with its systematic solutions, and became the  General Contractor of Jilin Zhengda Boiler, providing it with three 1.2 million kcal gas-fired thermal oil heaters, including pipe laying from the boiler room to the production floor.

how long does coal fired tube boiler last, ZOZEN molten salt heaters use molten potassium nitrate and sodium nitrite as heating media. Molten salt heater will heat the powder salt over the melting point until the viscosity of the molten salt allows circulating pump works, after the whole system is under circulating condition, then feed then into the thermal fluid heater for further circulating rising temperature to make it to be recycling used. Normal media working temperature is 400-550℃, top working temperature could reach 600℃.

how long does coal fired tube boiler last, With thermal efficiency over 82% and NOx emissions less than 100mg/Nm3, ZOZEN DZL series boilers feature high efficiency and low emissions. They adopt single-drum structure and a chain grate. The heat transfer coefficient of threaded smoke tubes is 1.8 times higher than ordinary tubes. In order to expand the capacity, PT. New Hope Indonesia introduced ZOZEN DZL series coal-fired steam boiler to provide efficient and reliable heat source guarantee for feed production. 

The structural design focuses more on details. The sealing of both sides of membrane wall and drums adopt comb plate. The boiler features a drainage system of condensation water in convection zone to prevent the corrosion of furnace body by acid condensate. Advantages: reduce the frequent maintenance of furnace and extend the boiler working life.

ZOZEN has set up a total of seven process stopping points throughout the production process, which are strictly controlled by different engineers, independent of each other and supervised each other, so that problems can be found and solved in time. If any workpiece is unqualified, it cannot enter the next process, which is the quality control of the entire production process of ZOZEN, how long does coal fired tube boiler last.

All boilers are subject to damage if proper water treatment procedures are not followed. This is an important consideration both during operation and when the boiler is idle. To avoid damage and costly repairs, monitor water chemistry routinely and ensure that you are supplying your boiler with soft water at all times.