bath natural gas steam fire tube boiler supplier, ZOZEN eco-friendly boilers meet the great demands of enterprises in Hebei Prvince

With emission requirements changing every day, it is also important to make sure that you are proactive when selecting equipment that will comply with future air regulations. Zozen Boiler has the most experience in selecting boiler equipment that will meet current and future NOx requirements.

During the processing of broilers, whether it is retort sterilization, baking and cooking, or heating and drying, the heat source provided by the steam boiler is required. ZOZEN successfully won the full recognition of the Chia Tai Group with its systematic solutions, and became the  General Contractor of Jilin Zhengda Boiler, providing it with three 1.2 million kcal gas-fired thermal oil heaters, including pipe laying from the boiler room to the production floor.

The SZS series oil-fired/gas-fired boiler proper adopts the D-type structure. One side is the furnace, and the other side is the convection heating surface. The partition walls around the furnace body, the partition wall between furnace and convection section, and the front and rear walls all adopt the membrane wall structure. There are foreign advanced burner, economizer and condenser installed at the end of flue gas duct, which can lower the exhaust gas temperature to 60℃, achieve the thermal efficiency of over 98% and control the emission of NOx to less than 30mg/Nm3. This kind of boiler has the characteristics of energy saving and environmental protection, safety and efficiency, simple operation and maintenance, and fully automatic control system which can realize unattended operation.

In the Harbin area, Heilongjiang Branch of Industrial and Commercial Bank of China, Harbin Investment Group, Harbin Coslight Battery, Veolia (Harbin) Thermal Power and other companies all use eco-friendly gas-fired boilers produced by ZOZEN. It is understood that in the industrial gas-fired boiler market, the coverage rate of ZOZEN gas-fired boiler is as high as 90%. This is not only due to the strength of ZOZEN with a wide range of boiler types and a capacity ranging from 1 to 110 tph, which can meet the demands of enterprise production and heating, but also due to the advantages of the boiler itself.

bath natural gas steam fire tube boiler supplier, ZOZEN gas/oil-fired boilers adopt the large furnace design with wide fuel adaptability and sufficient fuel combustion. With the energy-saving device at the end of the flue gas duct, the boiler can improve the thermal efficiency to 98% and above. ZOZEN gas/oil-fired boilers have good energy-saving and eco-friendly effects to easily realize the ultra low NOx emission.

ZOZEN Boiler has set up seven process stop points that are material re-inspection, material inspection number transfer, plate welding test, heat treatment, pre-expansion before welding, flaw detection inspection, hydrostatic test, which are inspected by seven responsible engineers. If any link is unqualified, it will not be able to proceed to the next process, which ensures that each ZOZEN boiler has the high quality, bath natural gas steam fire tube boiler supplier.

This quality mobilization meeting marked the start of ZOZEN’s quality improvement work. Quality is the life of an enterprise. For survival and development, every enterprise has to improve the product quality and keep innovation for higher goals. Next, ZOZEN Boiler will unremittingly pursue high quality for perfection with practical actions, so as to rank the top in the industrial boiler industry and write a new chapter for the quality of ZOZEN Boiler, bath natural gas steam fire tube boiler supplier.