use for textile mill fire tube, the emplyees of ZOZEN get good achiecements in the gas-fired boiler electric welding competition

On August 25 of 2020, Wuxi ZOZEN Boilers Co., Ltd. officially held the quality management mobilization meeting. The basic design department, research and development department, process improvement department, equipment department, production department, quality assurance department, purchasing department, material planning department, all workers at the production lines and related leadership attended the meeting.

use for textile mill fire tube, Relying on its solid strength, ZOZEN gained a new partner in the paper industry in Papua New Guinea - Pom Packaging. Due to the expansion of production capacity, Pom Packaging urgently needs to introduce multiple steam boilers with stable performance to meet production needs. Pom Packaging company fully affirmed ZOZEN's expertise in biomass boilers after in-depth technical exchanges, and then ordered multiple sets of 15tph SZL series biomass steam boilers.

ZOZEN’s YQ(Y)W series oil-fired/gas-fired vertical thermal oil heater adopts three-pass round coil structure whose end adopts conical coil which can effectively protect the furnace wall at the end of boiler. It is equipped with advanced combustion device with good energy saving and environmental protection performance. This kind of boiler has the characteristics of wide fuel adaptability, low pressure and high temperature, safety and efficiency, high thermal efficiency over 95%, and complete automatic control system which can realize unattended operation, use for textile mill fire tube.

use for textile mill fire tube, Meanwhile, a set of 36 tph ZOZEN DZL series biomass-fired boiler was in installation in Shandong Province. This boiler system would provide the stable heat source support for the production base of Heze Huihao Textile Co., Ltd. with an annual output of 3,000 tons of knitted fabric and 3,000 tons of rinsed knitted fabric. ZOZEN biomass-fired boiler had a reasonable primary and secondary air ratio and the SNCR intelligent denitrification device at the boiler end, which could ensure that the NOx emission concentration was less than 50mg/Nm3 to meet the environmental protection standards in Shandong Province, helping Huihao Textile realize the ultra-low NOx emission.

ZOZEN SZS series boiler body is designed with D-type chamber combustion structure. The furnace is on right side and the convection heating surface is on left side. The membrane type structure is adopted for the circumference of the furnace body, the wall between the furnace and the convection zone, the front and rear walls of boilers body. The furnace pressure is designed to be greater than 6000Pa.

The grate bracket of ZOZEN chain grate boilers adopts double-layer bracket. The upper layer uses light rail while the lower layer uses channel steel. The upper layer is heated while the lower layer is stressed. This has changed the traditional grate bracket structure which uses angle steel and friction bars and can avoid deformation. The active grate runs on the light rail. The 72-hour cold test run is carried out on the grate before the grate leaves the factory to ensure the smooth operation of the grate without deviation or jamming.

As a pioneer of energy saving and environmental protection technology, ZOZEN Boiler is stepping into a new era in the aspects of product development and enterprise culture. In order to realize the ultimate goal, ZOZEN builds close cooperative relationships with customers. The sales network of ZOZEN not only covers the whole country, but also reaches a lot of countries and regions all over the world. Based on the changes of industry trend and channel, ZOZEN divides the sales operation into three parts: operator channel, e-commerce and traditional channel. E-commerce adopts different sales strategies to support the development of ZOZEN, use for textile mill fire tube.