horizontal pellet boiler, ZOZEN optimizes the biomass boiler structure to improve the thermal efficiency

As a domestic well-known industrial boiler manufacturer, ZOZEN has been implementing the Belt and Road initiative all the time. The booming development in overseas market of ZOZEN profits from insisting on technological innovation and cultivating professional technical service team for overseas market.

horizontal pellet boiler, Relying on its solid strength, ZOZEN gained a new partner in the paper industry in Papua New Guinea - Pom Packaging. Due to the expansion of production capacity, Pom Packaging urgently needs to introduce multiple steam boilers with stable performance to meet production needs. Pom Packaging company fully affirmed ZOZEN's expertise in biomass boilers after in-depth technical exchanges, and then ordered multiple sets of 15tph SZL series biomass steam boilers.

horizontal pellet boiler, The base of ZOZEN DZL series coal-fired steam boiler adopts separate air chambers to keep the fuel on the grate in a good combustion state. The air dampers further ensure the sufficient combustion of the fuel and improve the fuel utilization. In addition, through advanced electrical control, it can realize the stepless speed regulation of the grate, as well as limit parameters alarm and interlock protection function to ensure the safe operation of the entire boiler system.

horizontal pellet boiler, ZOZEN biomass-fired boilers refer to the boilers fueled by biomass energy, which are typically energy-saving and eco-friendly products. Biomass fuel usually refers to the agricultural and forestry wastes such as various crop straws, leaves, wood chips and so on, which are renewable and recyclable. The operating cost of biomass-fired boilers is low, which is only a half of that of gas-fired boilers. However, the initial investment cost of biomass-fired boilers is higher than that of oil-fired or natural gas fired boilers. Biomass-fired boilers are good alternatives to gas-fired boilers when replacing the coal-fired boilers. At present, the technical parameters of biomass-fired boilers are 2-75 tph (rated capacity) and 2.0-116 MW (rated thermal power).

The grate bracket of ZOZEN chain grate boilers adopts double-layer bracket. The upper layer uses light rail while the lower layer uses channel steel. The upper layer is heated while the lower layer is stressed. This has changed the traditional grate bracket structure which uses angle steel and friction bars and can avoid deformation. The active grate runs on the light rail. The 72-hour cold test run is carried out on the grate before the grate leaves the factory to ensure the smooth operation of the grate without deviation or jamming.

horizontal pellet boiler, ZOZEN’s oil-fired/gas-fired skid-mounted steam boiler has obvious advantages of integrated skid-mounted delivery, compact structure and cost saving, which immediately attracted the attention and favor of the Myanmar Factory of Xindaxin Food after it came onto the market. ZOZEN had completed the customization of full set of skid-mounted boiler system to meet the actual requirements of the factory. After it is delivered to the boiler room of the Myanmar factory, it can run automatically with water, electricity and oil supply when the start button is pressed.

In recent days, ZOZEN YLW thermal oil heater was successfully shipped. It could be put into operation immediately by simply switching on the power. The easy installation will help Kay & Emms save a lot of installation cost.