chineese thermal oil boiler manufacturers, ZOZEN boiler, a gas-fired boiler brand has low failure rate and good performance

With air emission regulations constantly changing, ZOZEN Boiler has adopted new ways to keep up with more stringent standards. ZOZEN eco-friendly boilers were launched to the market, which come in various sizes. These eco-friendly boilers are more superior and efficient unlike traditional boilers as they smartly recycle heat that would be wasted.

ZOZEN Boiler focuses on the Thailand market and has reached a cooperative relationship with Cho Heng Rice Vermicelli Factory Co., Ltd. by virtue of strong overall corporate strength and rich project experience.

The DZL series coal-fired horizontal three-pass water-fire tube chain grate boiler is pre-assembled boiler which is safe and efficient with a thermal efficiency of over 82%. The boiler body is a single drum longitudinal layout. Thread smoke tubes in the drum form the convection heating surface while the drum and water-cooled walls on both sides form the radiation heating surface of the furnace. The combustion equipment adopts the light chain grate. It has the characteristics of wide coal adaptability, small covering area, convenient installation and high thermal efficiency.

chineese thermal oil boiler manufacturers, The IoT solution of ZOZEN Boiler has multiple subsystems such as equipment monitoring, expert management and so on. The boiler operator can monitor the overall operating status of boiler in real time through PC, APP and large screen, which realizes the real-time upload of fault alarms and video monitoring. At the same time, a boiler expert management knowledge base is established for common problems and treatment measures during boiler’s operation, which makes it possible for plan checking and expert online diagnosis, realizes the intelligent and precise management of each production base and further reduces the operating cost and improve the economic efficiency of the enterprise.

With the application of patented technology in chain grate furnace, ZOZEN has realized the high efficiency and low emission of DZL series steam boilers. The thermal efficiency can reach 82% and NOx emissions can be less than 100mg/Nm3, which not only improves the combustion efficiency but also reduces the operating costs and pollution emissions of enterprises, chineese thermal oil boiler manufacturers.

Meanwhile, a set of 36 tph ZOZEN DZL series biomass-fired boiler was in installation in Shandong Province. This boiler system would provide the stable heat source support for the production base of Heze Huihao Textile Co., Ltd. with an annual output of 3,000 tons of knitted fabric and 3,000 tons of rinsed knitted fabric. ZOZEN biomass-fired boiler had a reasonable primary and secondary air ratio and the SNCR intelligent denitrification device at the boiler end, which could ensure that the NOx emission concentration was less than 50mg/Nm3 to meet the environmental protection standards in Shandong Province, helping Huihao Textile realize the ultra-low NOx emission, chineese thermal oil boiler manufacturers.

In recent days, ZOZEN YLW thermal oil heater was successfully shipped. It could be put into operation immediately by simply switching on the power. The easy installation will help Kay & Emms save a lot of installation cost.