2014 hot sales wns steam boiler with burner, ZOZEN SZS series boiler adopts the flue gas backflow technology

On August 25 of 2020, Wuxi ZOZEN Boilers Co., Ltd. officially held the quality management mobilization meeting. The basic design department, research and development department, process improvement department, equipment department, production department, quality assurance department, purchasing department, material planning department, all workers at the production lines and related leadership attended the meeting.

On October 15, the SZL series steam boiler project which was the first cooperation between ZOZEN Boiler and Afghanistan Baheer Group officially started to supply steam. After 24 hours of test run of the boiler, ZOZEN steam boiler burned normally, the grate ran smoothly, and the alarm devices, pressure valves and other components were also working normally. From then on, ZOZEN steam boiler would become an important member of the company’s paper production line to provide the stable and efficient steam support.

The WNS series oil-fired/gas-fired boiler is a kind of fire tube wetback boiler with a two-pass or three-pass structure. It is equipped with foreign advanced burner, economizer and condenser installed at the end of flue gas duct to lower the exhaust temperature to 60℃, achieve the thermal efficiency of over 98% and control the emission of NOx to less than 30mg/Nm3. It has the characteristics of compact structure, small covering area, short installation period, easy operation and complete automatic control system which can realize unattended operation, 2014 hot sales wns steam boiler with burner.

Meanwhile, a set of 36 tph ZOZEN DZL series biomass-fired boiler was in installation in Shandong Province. This boiler system would provide the stable heat source support for the production base of Heze Huihao Textile Co., Ltd. with an annual output of 3,000 tons of knitted fabric and 3,000 tons of rinsed knitted fabric. ZOZEN biomass-fired boiler had a reasonable primary and secondary air ratio and the SNCR intelligent denitrification device at the boiler end, which could ensure that the NOx emission concentration was less than 50mg/Nm3 to meet the environmental protection standards in Shandong Province, helping Huihao Textile realize the ultra-low NOx emission.

2014 hot sales wns steam boiler with burner, Based on the requirements of GB standard, the straight plug type water level electrode on the top of the furnace is added to prevent a shortage of water in the boiler due to wrong operation or other reasons. Advantages: avoid water shortage when the boiler is running.

The grate bracket of ZOZEN chain grate boilers adopts double-layer bracket. The upper layer uses light rail while the lower layer uses channel steel. The upper layer is heated while the lower layer is stressed. This has changed the traditional grate bracket structure which uses angle steel and friction bars and can avoid deformation. The active grate runs on the light rail. The 72-hour cold test run is carried out on the grate before the grate leaves the factory to ensure the smooth operation of the grate without deviation or jamming.

In recent days, ZOZEN YLW thermal oil heater was successfully shipped. It could be put into operation immediately by simply switching on the power. The easy installation will help Kay & Emms save a lot of installation cost, 2014 hot sales wns steam boiler with burner.