25 mv fire tube boiler project in pakistan, ZOZEN boiler, an expert of industrial boiler manufacturing, gives you a detailed answer

The price of fuel is constantly fluctuating and with it comes creative ways to be more economical. Finding methods to be more energy efficient is never a waste of time. In the boiler room, efficiency improvements can be found by many sources, however, a common option for energy savings includes the use of an economizer. NOW, ZOZEN will help introduce the economizer. The economizer is a fabricated assembly of finned tubing that captures waste heat extracted from the boiler’s stack flue gases the exhaust that leaves the boiler stack, 25 mv fir tube boiler project in pakistan.

Recently, data from the National Bureau of Statistics showed that China’s industrial boiler output from January to July in 2020 was 184,780.8 tph, a decrease of 24.8% year-on-year, showing a downward trend. Against the background of a sharp decline in the domestic industrial boiler industry, ZOZEN Boiler managed to overcome the difficulties and achieved a slight increase in output.

ZOZEN YLW series thermal oil heater is of square coil tube vertical type chain grate, it consists of two separate parts - chain grate stoker and heater body. After erection on site, it only needs to connect to thermal oil piping and electricity to start operation. The heater adopts chain grate to perform mechanical fuel feeding, equipped with FD fan and ID fan for air ventilation, and also equipped with slay discharger to remove the bottom slag, 25 mv fir tube boiler project in pakistan.

Meanwhile, a set of 36 tph ZOZEN DZL series biomass-fired boiler was in installation in Shandong Province. This boiler system would provide the stable heat source support for the production base of Heze Huihao Textile Co., Ltd. with an annual output of 3,000 tons of knitted fabric and 3,000 tons of rinsed knitted fabric. ZOZEN biomass-fired boiler had a reasonable primary and secondary air ratio and the SNCR intelligent denitrification device at the boiler end, which could ensure that the NOx emission concentration was less than 50mg/Nm3 to meet the environmental protection standards in Shandong Province, helping Huihao Textile realize the ultra-low NOx emission.

ZOZEN WNS series gas fired boiler not only adopts advanced low NOx burners. And through the flue gas recirculation technology, about 10% -30% of the flue gas at the tail of the boiler is sucked into the air inlet of the burner through the flue gas pipe, mixed with the combustion-supporting air, and then entering the furnace, thereby reducing the temperature and oxygen concentration in the combustion area, and finally reducing The amount of thermal NOx is generated, and the NOx in the tail gas of the boiler are less than 30mg/Nm3, which meets the requirements of low nitrogen emissions of the enterprise.enterprise.

ZOZEN has a number of leading automatic welding, rolling, assembly production lines and hydraulic test workshops in the industry, which fully ensure the quality of the butt joints of the pipes, as well as the inner ring, middle ring and outer ring disks during the production of the heat-conducting oil boiler body. Assembly accuracy between tubes.

As a well-known industrial boiler manufacturer, ZOZEN Boiler actively responds to the Belt and Road Initiative, pays attention to developing advantages of technology, brand and service, conforms to the global development trend, contributes to the economic development of the “Belt and Road” countries and regions with safe and efficient boiler equipment, and rapidly expands the overseas market.