2t boiler manufacturing companies nepal, ZOZEN Boiler creates job opportunities for many people

2t boiler manufacturing companies nepal, The new era creates new demands. As the economic growth gradually changes from extensive type to intensive and eco-friendly type, all industries are facing unlimited opportunities and challenges. ZOZEN Boiler, as a typical representative of industrial boiler manufacturers, has promoted the transformation and upgrading of various industries with the eco-friendly gas-fired boilers, which not only helps the cooperative partners of ZOZEN Boiler achieve the green development, but also proves the value of itself.

On September 30, the Ministry of Industry and Information Technology released the "Energy Efficiency Star" Product Catalog (2018) on its official website. "Energy Efficiency Star" products refer to mass-produced products that are more energy-efficient than similar products on the basis of energy-saving products. They aim to promote the promotion and application of energy-efficient products, lead innovation in energy-saving technologies, change consumer orientation, and enhance energy-saving concepts. ZOZEN SZS series gas-fired steam boiler (SZS75-1.6/300-Q) ranked honorably on the list with its excellent energy saving and emission reduction advantages.

ZOZEN Boiler's Pressure Components Receive Hydrostatic Test

ZOZEN WNS series and SZS series gas-fired boilers are popular in the Mexican market for the thermal efficiency which is over 98% and NOx emission which is less than 30mg/Nm3, and for the good energy-saving and eco-friendly performance. At the same time, in response to the customer’s demand for using two gases as fuel, ZOZEN Boiler changed the burner configuration and tailored the whole boiler system for the customer, which was recognized and favored by the customer.

2t boiler manufacturing companies nepal, ZOZEN WNS series gas fired boiler not only adopts advanced low NOx burners. And through the flue gas recirculation technology, about 10% -30% of the flue gas at the tail of the boiler is sucked into the air inlet of the burner through the flue gas pipe, mixed with the combustion-supporting air, and then entering the furnace, thereby reducing the temperature and oxygen concentration in the combustion area, and finally reducing The amount of thermal NOx is generated, and the NOx in the tail gas of the boiler are less than 30mg/Nm3, which meets the requirements of low nitrogen emissions of the enterprise.enterprise.

Starting from the steel sheet blanking, every key process of ZOZEN adopts advanced CNC processing technology, which ensures the quality of the boiler and shortens the delivery time. Efficient automated production lines, sufficient raw material stocking, and scientific 6S on-site management ensure that multiple SZS series gas-fired hot water boilers are delivered with high quality within the agreed time.

Meanwhile, a set of 36 tph ZOZEN DZL series biomass-fired boiler was in installation in Shandong Province. This boiler system would provide the stable heat source support for the production base of Heze Huihao Textile Co., Ltd. with an annual output of 3,000 tons of knitted fabric and 3,000 tons of rinsed knitted fabric. ZOZEN biomass-fired boiler had a reasonable primary and secondary air ratio and the SNCR intelligent denitrification device at the boiler end, which could ensure that the NOx emission concentration was less than 50mg/Nm3 to meet the environmental protection standards in Shandong Province, helping Huihao Textile realize the ultra-low NOx emission.

In recent days, ZOZEN YLW thermal oil heater was successfully shipped. It could be put into operation immediately by simply switching on the power. The easy installation will help Kay & Emms save a lot of installation cost.