3ton coal fired boiler for garment factory, focusing on talent cultivation, the Wuxi gas-gired boiler manufacturer, ZOZEN boiler, has a promising future

Over the past 30 years, ZOZEN Boiler has always adhered to the scientific management mode of modern enterprises, has always insisted on the spirit of “devotion, precision, strictness and harmony”, and has always striven for the development goal of “pursuing excellence, building a competitive brand and revitalizing the national industry”.

3ton coal fired boiler for garment factory, MCC Ltd has successful become ZOZEN’s distributor in Bangladesh, which further deepens the development of ZOZEN’s global business.

ZOZEN has realized automatic welding of the longitudinal seam

ZOZEN SZL series biomass-fired boiler is the horizontal dual cylinder arranged, chain grating,  steam and hot water boiler designed by ZOZEN technical personnel according to advanced technology and experiences from domestic and international boiler market. The technology, performance and environment protective data of this series of products reach the international advanced level , and this product is the mainstay one in boiler industry.

ZOZEN biomass-fired boilers refer to the boilers fueled by biomass energy, which are typically energy-saving and eco-friendly products. Biomass fuel usually refers to the agricultural and forestry wastes such as various crop straws, leaves, wood chips and so on, which are renewable and recyclable. The operating cost of biomass-fired boilers is low, which is only a half of that of gas-fired boilers. However, the initial investment cost of biomass-fired boilers is higher than that of oil-fired or natural gas fired boilers. Biomass-fired boilers are good alternatives to gas-fired boilers when replacing the coal-fired boilers. At present, the technical parameters of biomass-fired boilers are 2-75 tph (rated capacity) and 2.0-116 MW (rated thermal power).

For more than 30 years, ZOZEN Boiler has always put the product quality in the first place. Under the strict quality management system, the relevant personnel of hydrostatic test strictly follows the Boiler Safety Technical Supervision Regulations. The working pressure and test pressure should be carefully implemented according to the drawings to ensure that each boiler hydrostatic test is successfully completed.

3ton coal fired boiler for garment factory, Meanwhile, a set of 36 tph ZOZEN DZL series biomass-fired boiler was in installation in Shandong Province. This boiler system would provide the stable heat source support for the production base of Heze Huihao Textile Co., Ltd. with an annual output of 3,000 tons of knitted fabric and 3,000 tons of rinsed knitted fabric. ZOZEN biomass-fired boiler had a reasonable primary and secondary air ratio and the SNCR intelligent denitrification device at the boiler end, which could ensure that the NOx emission concentration was less than 50mg/Nm3 to meet the environmental protection standards in Shandong Province, helping Huihao Textile realize the ultra-low NOx emission.

As an important member of boiler manufacturers, ZOZEN Boiler will always comply with standards and specifications, adhere to the original intention, insist on innovation, improve the product quality and enhance the product performance to provide more and better boilers for customers and make contributions to the boiler industry.