horizontal industrial biomass fired boiler, ZOZEN boiler has outstanding energy-saving and environmental protection effects
As a kind of special equipment widely used in the industrial production, boilers require more strict requirements for manufacturers for the improvement of boiler performance and parameters. Wuxi ZOZEN Boilers Co., Ltd. is a professional A-grade boiler manufacturer engaged in the boiler industry for more than 30 years. The company has strong comprehensive strength, a wide range of products (boiler working pressure can be up to 5.4 Mpa), and abundant project experience, horizontal industrial biomass fired boiler.
horizontal industrial biomass fired boiler, On December 16, the owner and agents made a field visit of the informationalized plant of ZOZEN Boiler, and formally signed a purchasing contract with ZOZEN Boiler on the WNS series gas-fired hot water boilers.
ZOZEN DZL series coal-fired steam boiler has sufficient output and high thermal efficiency. The boiler is packaged with a compact structure, so it has relatively low construction costs. The boiler is a horizontal three-pass water and fire tube chain grate boiler. In the single drum with a longitudinal layout, threaded smoke tubes from the convection heating surface, while the boiler drum and water-cooled walls on both sides form the radiation heating surface in the furnace. The boiler thermal efficiency can reach 82% and above.
ZOZEN WNS series boiler is designed with large-diameter corrugated furnace and wet-back structure. Depending on the velocity of different flue gas, proper heat transfer element will be selected. Advantages:high efficiency, low back pressure, ultra-low NOx emissions.
ZOZEN has a number of leading automatic welding, rolling, assembly production lines and hydraulic test workshops in the industry, which fully ensure the quality of the butt joints of the pipes, as well as the inner ring, middle ring and outer ring disks during the production of the heat-conducting oil boiler body. Assembly accuracy between tubes.
Meanwhile, a set of 36 tph ZOZEN DZL series biomass-fired boiler was in installation in Shandong Province. This boiler system would provide the stable heat source support for the production base of Heze Huihao Textile Co., Ltd. with an annual output of 3,000 tons of knitted fabric and 3,000 tons of rinsed knitted fabric. ZOZEN biomass-fired boiler had a reasonable primary and secondary air ratio and the SNCR intelligent denitrification device at the boiler end, which could ensure that the NOx emission concentration was less than 50mg/Nm3 to meet the environmental protection standards in Shandong Province, helping Huihao Textile realize the ultra-low NOx emission.
If you’re looking for more information about industrial boiler maintenance, ZOZEN has put together a checklist for you. Implementing routine boiler maintenance can result in operational efficiency, cost savings and safer work conditions for your company.
-
In the industrial zone of Wen’an County, Xinghua Cable Co., Ltd. is making steady progress on its project with an annual production capacity of 11 million meters of wires, cables, and accessories, backed by an investment of RMB 520 million. Upon completion, the project is expected to create over 150 jobs and generate annual sales revenue of RMB 800 million, demonstrating promising prospects. As a key supplier of thermal energy equipment, ZOZEN Boiler is quietly supporting the development o...22 Jul 2025
-
On March 20, 2025, the Guizhou Jinyuan Zhijin “Replacing Small Units with Large Ones” Relocation Project (2×660 MW), under State Power Investment Corporation, successfully achieved the first ignition of its boiler. This project replaced traditional oil-fired ignition fuel with liquefied natural gas (LNG), setting a new precedent for employing clean energy in 660 MW ultra-supercritical “W” flame boilers. As a key equipment supplier for this project, ZOZEN Boiler prov...15 Jul 2025
-
Under the Belt and Road Initiative, economic and cultural ties between China and Pakistan are growing ever stronger, with more frequent exchanges between businesses from both countries. Recently, ZOZEN Boiler’s Sales Director led a team to visit Pakistan, where they held a meaningful meeting with Kohinoor Mills, a leading local textile company. During the gathering, both sides exchanged honorary plaques and thoughtful gifts—gestures that not only celebrate past collaborations but als...08 Jul 2025
Find the Right Boiler For You
-
Email us
-
WhatsApp: +86 18861589035
WeChat: +86 13506150756
Live Chat