40 tph 87 bar gas oil fired boilers, ZOZEN biomass-fired boilers have a wide fuel adaptability to various biomass fuels

40 tph 87 bar gas oil fired boilers, The new era creates new demands. As the economic growth gradually changes from extensive type to intensive and eco-friendly type, all industries are facing unlimited opportunities and challenges. ZOZEN Boiler, as a typical representative of industrial boiler manufacturers, has promoted the transformation and upgrading of various industries with the eco-friendly gas-fired boilers, which not only helps the cooperative partners of ZOZEN Boiler achieve the green development, but also proves the value of itself.

40 tph 87 bar gas oil fired boilers, ZOZEN DHL series coal-fired water tube hot water boiler is popularized and applied in Liaoning Province, and is also an ideal heating equipment for central heating.

40 tph 87 bar gas oil fired boilers, ZOZEN YLW series thermal oil heater is of square coil tube vertical type chain grate, it consists of two separate parts - chain grate stoker and heater body. After erection on site, it only needs to connect to thermal oil piping and electricity to start operation. The heater adopts chain grate to perform mechanical fuel feeding, equipped with FD fan and ID fan for air ventilation, and also equipped with slay discharger to remove the bottom slag.

ZOZEN biomass-fired boilers refer to the boilers fueled by biomass energy, which are typically energy-saving and eco-friendly products. Biomass fuel usually refers to the agricultural and forestry wastes such as various crop straws, leaves, wood chips and so on, which are renewable and recyclable. The operating cost of biomass-fired boilers is low, which is only a half of that of gas-fired boilers. However, the initial investment cost of biomass-fired boilers is higher than that of oil-fired or natural gas fired boilers. Biomass-fired boilers are good alternatives to gas-fired boilers when replacing the coal-fired boilers. At present, the technical parameters of biomass-fired boilers are 2-75 tph (rated capacity) and 2.0-116 MW (rated thermal power).

The waveform stove furnace is an important part of the WNS series of oil-fired/gas-fired boiler. This part is directly exposed to the radiation of high-temperature flame and erosion of high-temperature flue gas. The use of the axial expansion and contraction of waveform stove furnace can reduce the thermal stress generated by the shell, tube plate and furnace itself, and more importantly, reduce the stress concentration caused by the elongation of furnace at the connection between furnace and tube plate. At the same time, the waveform stove furnace strengthens the flue gas disturbance, effectively improves the heat transfer effect of unit area and volume, and further improves the thermal efficiency of boiler.

The industrial boiler plays an important role in the development of the beverage industry. The boiler equipment is directly related to the output and quality of beverages. As a well-known industrial boiler manufacturer, ZOZEN has provided boilers for many beverage industry giants such as Coca-Cola, Want Want, Nongfu Spring, Wahaha, Jianlibao, etc.

In recent years, attention to environmental protection and sustainable development has been raised to a new height. Both Lenzing Group and ZOEN Boiler are constantly practicing the concept of sustainable development. There may still be new challenges in the future, but as a large-scale enterprise with social responsibility, ZOZEN Boiler will continue to insist on technological innovation and work with partners to achieve the unified development of economic, environmental and social benefits.